Raspberry Pi as MySensors gateway crash/hung after ~1hour.



  • Hello,

    I am using MySensors since 2 years. To this day I was using UNO with W5100 shield as Ethernet gateway for my nodes (beta branch). Today I migrated to Raspberry Pi gateway solution with nrf24l01+ PA option. Everything went smooth, I have installed development branch etc, radio has been initialised and all the sensors/nodes were replaced with the new ones. I have tested this for few hours and I can see that after some time (approx 1-2h) MySensors data reporting is hung/stuck. The only way to fix it is reboot of the system.

    Could you please take a look on below and advise what can be wrong? As you can see MySensors logs are being sent/received till Dec 29 22:01:37. After this timestamp only "ping" is working, no new data in the channel. I was using similar solution on 2nd Pi (same config) and this runs for a weeks without any problems. I would like to avoid migrating back to W5100 solution because I need to have ability to check MySensors logs remotely.

    Thank you for the help.
    Maciek

    For the reference:

    ## CONFIGURATION
    pi@raspberrypi ~/MySensors $ ./configure --my-debug=enable --my-transport=nrf24 --my-gateway=ethernet --my-port=5003 --my-rf24-pa-level=RF24_PA_LOW --my-rf24-irq-pin=15 --my-leds-err-pin=12 --my-leds-rx-pin=16 --my-leds-tx-pin=18
    [SECTION] Detecting target machine.
      [OK] machine detected: SoC=BCM2836, Type=rpi2, CPU=armv7l.
    [SECTION] Detecting SPI driver.
      [OK] SPI driver detected:BCM.
    [SECTION] Detecting init system.
      [OK] init system detected: systemd.
    [SECTION] Saving configuration.
    [SECTION] Cleaning previous builds.
    [OK] Finished.
    
    ## DEBUG ENABLED in /etc/systemd/system/mysgw.service
    [Service]
    ExecStart=/usr/local/bin/mysgw -d
    
    ## VERIFICATION
    pi@raspberrypi ~/MySensors $ sudo ./bin/mysgw -d
    mysgw: Starting gateway...
    mysgw: Protocol version - 2.2.0-rc.2
    mysgw: MCO:BGN:INIT GW,CP=RNNGL-Q-,VER=2.2.0-rc.2
    mysgw: TSF:LRT:OK
    mysgw: TSM:INIT
    mysgw: TSF:WUR:MS=0
    mysgw: TSM:INIT:TSP OK
    mysgw: TSM:INIT:GW MODE
    mysgw: TSM:READY:ID=0,PAR=0,DIS=0
    mysgw: MCO:REG:NOT NEEDED
    mysgw: Listening for connections on 0.0.0.0:5003
    mysgw: MCO:BGN:STP
    mysgw: MCO:BGN:INIT OK,TSP=1
    mysgw: TSF:MSG:READ,49-49-255,s=255,c=3,t=7,pt=0,l=0,sg=0:
    mysgw: TSF:MSG:BC
    mysgw: TSF:MSG:FPAR REQ,ID=49
    mysgw: TSF:CKU:OK,FCTRL
    mysgw: TSF:MSG:GWL OK
    mysgw: TSF:MSG:SEND,0-0-49-49,s=255,c=3,t=8,pt=1,l=1,sg=0,ft=0,st=OK:0
    mysgw: TSF:MSG:READ,49-49-0,s=255,c=3,t=24,pt=1,l=1,sg=0:1
    mysgw: TSF:MSG:PINGED,ID=49,HP=1
    mysgw: TSF:MSG:SEND,0-0-49-49,s=255,c=3,t=25,pt=1,l=1,sg=0,ft=0,st=OK:1
    mysgw: TSF:MSG:READ,4-4-0,s=0,c=1,t=37,pt=2,l=2,sg=0:209
    mysgw: TSF:MSG:READ,4-4-0,s=2,c=1,t=0,pt=7,l=5,sg=0:-0.4
    mysgw: TSF:MSG:READ,4-4-0,s=1,c=1,t=1,pt=7,l=5,sg=0:99.9
    
    
    ## DAILY,NORMAL OPERATION AFTER 1ST REBOOT
    Dec 29 22:00:57 raspberrypi mysgw: Client 0: 0;0;3;0;18;PING
    Dec 29 22:00:57 raspberrypi mysgw: TSF:MSG:READ,3-3-0,s=4,c=1,t=0,pt=7,l=5,sg=0:-0.5
    Dec 29 22:00:58 raspberrypi mysgw: TSF:MSG:READ,8-3-0,s=1,c=1,t=34,pt=7,l=5,sg=0:0.00
    Dec 29 22:00:58 raspberrypi mysgw: TSF:MSG:READ,8-3-0,s=1,c=1,t=24,pt=5,l=4,sg=0:498046
    Dec 29 22:00:58 raspberrypi mysgw: TSF:MSG:READ,8-3-0,s=1,c=1,t=35,pt=7,l=5,sg=0:498.046
    Dec 29 22:00:58 raspberrypi mysgw: TSF:MSG:READ,3-3-0,s=5,c=1,t=0,pt=7,l=5,sg=0:25.0
    Dec 29 22:00:59 raspberrypi mysgw: TSF:MSG:READ,3-3-0,s=6,c=1,t=0,pt=7,l=5,sg=0:30.1
    Dec 29 22:00:59 raspberrypi mysgw: TSF:MSG:READ,4-4-0,s=0,c=1,t=37,pt=2,l=2,sg=0:208
    Dec 29 22:00:59 raspberrypi mysgw: TSF:MSG:READ,3-3-0,s=7,c=1,t=0,pt=7,l=5,sg=0:20.6
    Dec 29 22:01:01 raspberrypi mysgw: TSF:MSG:READ,4-4-0,s=2,c=1,t=0,pt=7,l=5,sg=0:-0.4
    Dec 29 22:01:01 raspberrypi mysgw: TSF:MSG:READ,4-4-0,s=1,c=1,t=1,pt=7,l=5,sg=0:99.9
    Dec 29 22:01:01 raspberrypi CRON[3866]: (pi) CMD (sudo ~/domoticz/scripts/readapc.sh >/dev/null 2>&1)
    Dec 29 22:01:01 raspberrypi CRON[3867]: (pi) CMD (sleep 20; sudo ~/domoticz/scripts/readapc.sh >/dev/null 2>&1)
    Dec 29 22:01:01 raspberrypi CRON[3871]: (pi) CMD (sleep 40; sudo ~/domoticz/scripts/readapc.sh >/dev/null 2>&1)
    Dec 29 22:01:02 raspberrypi mysgw: TSF:MSG:READ,49-49-0,s=1,c=1,t=0,pt=7,l=5,sg=0:20.0
    Dec 29 22:01:02 raspberrypi mysgw: TSF:MSG:READ,49-49-0,s=0,c=1,t=4,pt=7,l=5,sg=0:1012
    Dec 29 22:01:07 raspberrypi mysgw: Client 0: 0;0;3;0;18;PING
    Dec 29 22:01:09 raspberrypi mysgw: TSF:MSG:READ,1-1-0,s=1,c=1,t=17,pt=5,l=4,sg=0:633
    Dec 29 22:01:09 raspberrypi mysgw: TSF:MSG:READ,1-1-0,s=1,c=1,t=24,pt=5,l=4,sg=0:12879042
    Dec 29 22:01:09 raspberrypi mysgw: TSF:MSG:READ,1-1-0,s=1,c=1,t=18,pt=7,l=5,sg=0:8586.0283
    Dec 29 22:01:12 raspberrypi mysgw: TSF:MSG:READ,7-3-0,s=1,c=1,t=24,pt=5,l=4,sg=0:34590149
    Dec 29 22:01:13 raspberrypi mysgw: TSF:MSG:READ,7-3-0,s=1,c=1,t=35,pt=7,l=5,sg=0:345901.469
    Dec 29 22:01:13 raspberrypi mysgw: TSF:MSG:READ,3-3-0,s=199,c=1,t=17,pt=5,l=4,sg=0:136
    Dec 29 22:01:14 raspberrypi mysgw: TSF:MSG:READ,3-3-0,s=199,c=1,t=24,pt=5,l=4,sg=0:1468990
    Dec 29 22:01:14 raspberrypi mysgw: TSF:MSG:READ,3-3-0,s=199,c=1,t=18,pt=7,l=5,sg=0:1468.9900
    Dec 29 22:01:15 raspberrypi mysgw: TSF:MSG:READ,3-3-0,s=0,c=1,t=0,pt=7,l=5,sg=0:26.9
    Dec 29 22:01:15 raspberrypi mysgw: TSF:MSG:READ,7-3-0,s=3,c=1,t=0,pt=7,l=5,sg=0:21.5
    Dec 29 22:01:16 raspberrypi mysgw: TSF:MSG:READ,7-3-0,s=2,c=1,t=1,pt=7,l=5,sg=0:44.1
    Dec 29 22:01:16 raspberrypi mysgw: TSF:MSG:READ,3-3-0,s=1,c=1,t=0,pt=7,l=5,sg=0:12.0
    Dec 29 22:01:16 raspberrypi mysgw: TSF:MSG:READ,3-3-0,s=2,c=1,t=0,pt=7,l=5,sg=0:50.6
    Dec 29 22:01:16 raspberrypi mysgw: TSF:MSG:READ,2-49-0,s=1,c=1,t=0,pt=7,l=5,sg=0:9.1
    Dec 29 22:01:16 raspberrypi mysgw: TSF:MSG:READ,2-49-0,s=0,c=1,t=1,pt=7,l=5,sg=0:52.3
    Dec 29 22:01:16 raspberrypi mysgw: TSF:MSG:READ,2-49-0,s=0,c=1,t=1,pt=7,l=5,sg=0:52.3
    Dec 29 22:01:17 raspberrypi mysgw: Client 0: 0;0;3;0;18;PING
    Dec 29 22:01:17 raspberrypi mysgw: TSF:MSG:READ,3-3-0,s=3,c=1,t=0,pt=7,l=5,sg=0:21.5
    Dec 29 22:01:17 raspberrypi mysgw: TSF:MSG:READ,3-3-0,s=4,c=1,t=0,pt=7,l=5,sg=0:-0.5
    Dec 29 22:01:18 raspberrypi mysgw: TSF:MSG:READ,8-3-0,s=1,c=1,t=24,pt=5,l=4,sg=0:498046
    Dec 29 22:01:18 raspberrypi mysgw: TSF:MSG:READ,3-3-0,s=5,c=1,t=0,pt=7,l=5,sg=0:25.0
    Dec 29 22:01:19 raspberrypi mysgw: TSF:MSG:READ,3-3-0,s=6,c=1,t=0,pt=7,l=5,sg=0:30.1
    Dec 29 22:01:19 raspberrypi mysgw: TSF:MSG:READ,4-4-0,s=0,c=1,t=37,pt=2,l=2,sg=0:213
    Dec 29 22:01:19 raspberrypi mysgw: TSF:MSG:READ,3-3-0,s=7,c=1,t=0,pt=7,l=5,sg=0:20.6
    Dec 29 22:01:21 raspberrypi mysgw: TSF:MSG:READ,4-4-0,s=2,c=1,t=0,pt=7,l=5,sg=0:-0.4
    Dec 29 22:01:21 raspberrypi mysgw: TSF:MSG:READ,4-4-0,s=1,c=1,t=1,pt=7,l=5,sg=0:99.9
    Dec 29 22:01:27 raspberrypi mysgw: Client 0: 0;0;3;0;18;PING
    Dec 29 22:01:29 raspberrypi mysgw: TSF:MSG:READ,1-1-0,s=1,c=1,t=17,pt=5,l=4,sg=0:635
    Dec 29 22:01:29 raspberrypi mysgw: TSF:MSG:READ,1-1-0,s=1,c=1,t=24,pt=5,l=4,sg=0:12879047
    Dec 29 22:01:29 raspberrypi mysgw: TSF:MSG:READ,1-1-0,s=1,c=1,t=18,pt=7,l=5,sg=0:8586.0312
    Dec 29 22:01:31 raspberrypi mysgw: TSF:MSG:READ,49-49-0,s=1,c=1,t=0,pt=7,l=5,sg=0:20.0
    Dec 29 22:01:32 raspberrypi mysgw: TSF:MSG:READ,49-49-0,s=0,c=1,t=4,pt=7,l=5,sg=0:1012
    Dec 29 22:01:32 raspberrypi mysgw: TSF:MSG:READ,7-3-0,s=1,c=1,t=34,pt=7,l=5,sg=0:15.98
    Dec 29 22:01:33 raspberrypi mysgw: TSM:READY:NWD REQ
    Dec 29 22:01:33 raspberrypi mysgw: TSF:MSG:SEND,0-0-255-255,s=255,c=3,t=20,pt=0,l=0,sg=0,ft=0,st=OK:
    Dec 29 22:01:33 raspberrypi mysgw: TSF:MSG:READ,7-3-0,s=1,c=1,t=24,pt=5,l=4,sg=0:34590150
    Dec 29 22:01:33 raspberrypi mysgw: TSF:MSG:READ,1-1-0,s=255,c=3,t=21,pt=1,l=1,sg=0:0
    Dec 29 22:01:33 raspberrypi mysgw: TSF:MSG:READ,49-49-0,s=255,c=3,t=21,pt=1,l=1,sg=0:0
    Dec 29 22:01:33 raspberrypi mysgw: TSF:MSG:READ,0-49-255,s=255,c=3,t=20,pt=0,l=0,sg=0:
    Dec 29 22:01:33 raspberrypi mysgw: TSF:MSG:BC
    Dec 29 22:01:33 raspberrypi mysgw: TSF:MSG:READ,7-3-0,s=1,c=1,t=35,pt=7,l=5,sg=0:345901.531
    Dec 29 22:01:33 raspberrypi mysgw: TSF:MSG:READ,3-3-0,s=199,c=1,t=17,pt=5,l=4,sg=0:136
    Dec 29 22:01:34 raspberrypi mysgw: TSF:MSG:READ,3-3-0,s=199,c=1,t=24,pt=5,l=4,sg=0:1468990
    Dec 29 22:01:34 raspberrypi mysgw: TSF:MSG:READ,3-3-0,s=199,c=1,t=18,pt=7,l=5,sg=0:1468.9900
    Dec 29 22:01:37 raspberrypi mysgw: Client 0: 0;0;3;0;18;PING
    Dec 29 22:01:47 raspberrypi mysgw: Client 0: 0;0;3;0;18;PING
    Dec 29 22:01:57 raspberrypi mysgw: Client 0: 0;0;3;0;18;PING
    Dec 29 22:02:01 raspberrypi CRON[4013]: (pi) CMD (sleep 40; sudo ~/domoticz/scripts/readapc.sh >/dev/null 2>&1)
    Dec 29 22:02:01 raspberrypi CRON[4019]: (pi) CMD (sleep 20; sudo ~/domoticz/scripts/readapc.sh >/dev/null 2>&1)
    Dec 29 22:02:01 raspberrypi CRON[4021]: (pi) CMD (sudo ~/domoticz/scripts/readapc.sh >/dev/null 2>&1)
    Dec 29 22:02:07 raspberrypi mysgw: Client 0: 0;0;3;0;18;PING
    Dec 29 22:02:17 raspberrypi mysgw: Client 0: 0;0;3;0;18;PING
    Dec 29 22:02:27 raspberrypi mysgw: Client 0: 0;0;3;0;18;PING
    Dec 29 22:02:37 raspberrypi mysgw: Client 0: 0;0;3;0;18;PING
    Dec 29 22:02:47 raspberrypi mysgw: Client 0: 0;0;3;0;18;PING
    Dec 29 22:02:57 raspberrypi mysgw: Client 0: 0;0;3;0;18;PING
    Dec 29 22:03:01 raspberrypi CRON[4164]: (pi) CMD (sleep 20; sudo ~/domoticz/scripts/readapc.sh >/dev/null 2>&1)
    Dec 29 22:03:01 raspberrypi CRON[4163]: (pi) CMD (sudo ~/domoticz/scripts/readapc.sh >/dev/null 2>&1)
    Dec 29 22:03:01 raspberrypi CRON[4165]: (pi) CMD (sleep 40; sudo ~/domoticz/scripts/readapc.sh >/dev/null 2>&1)
    Dec 29 22:03:07 raspberrypi mysgw: Client 0: 0;0;3;0;18;PING
    Dec 29 22:03:17 raspberrypi mysgw: Client 0: 0;0;3;0;18;PING
    Dec 29 22:03:27 raspberrypi mysgw: Client 0: 0;0;3;0;18;PING
    Dec 29 22:03:37 raspberrypi mysgw: Client 0: 0;0;3;0;18;PING

  • Mod

    @macieiks Could be power and/or radio related. Could you try with a different, non-PA radio ?


Log in to reply
 

Suggested Topics

0
Online

11.2k
Users

11.1k
Topics

112.5k
Posts